12-993-002FIRE SPRINKLER SYSTEM PLAN
SCALE: 1/4"=V-0"
tqCD Fire & Building
Products
Technical Services: Tel: (800) 381 -9312 / Fax: (800) 791 -5500
..
oeriles , r -ruts -- z,S 4.2 5.6 ant[ 8.0 K- factor
Upright, Pendent, and RecessedPendent Sprinklers
Quick response, Standard Coverage
General
Description
The Series TY FRB, 2.8, 4.2, 5.6, and
8.0 K- factor, Upright and Pendent
Sprinklers described in this data sheet
are quick response - standard cover-
age. decorative 3 mm glass bulb type
spray sprinklers designed for use in
light or ordinary hazard, commercial
occupancies such as banks, hotels.
shopping mails, etc.
The recessed version of the Series
TYFRB Pendent Sprinkler, where ap-
plicable, is intended for use in areas
with a finished ceiling. It uses either a
two -piece Style 10 (112 inch NPT) or
Style 40 (314 inch NPT) Recessed Es-
cutcheon with 112 inch (12,7 mm) of
recessed adjustment or up to 314 inch
09,1 mm) Of total adjustment from the
flush pendent position, or a two-piece
Style 20 O 11 inch NPT) or Style 30 (3(4
inch NPT) Recessed Escutcheon with
1/4 inch (6.4 mm) of recessed adjust-
ment or up to 1)2 inch (12,7 mm) of
total adjustment from the flush pen-
dent position. The adjustment provided
by the Recessed Escutcheon reduces
the accuracy to which the fixed pipe
drops to the sprinklers must be cut.
Corrosion resistant coatings, where
applicable, are utilized to extend the
life of copper alloy sprinklers beyond
that which would otherwise be ob.
tained when exposed to corrosive at-
mospheres. Although corrosion psis -
tant coated sprinklers have passdthe
standard corrosion tests of the appli-
cable approval agencies, the testng is
not representative of all possible cor-
rosive atmospheres. Consequeny, it
is recommended that the end use be
consulted with respect to the suitability
Of these coatings for any given corro.
sive environment. The effects of anbi-
ent temperature, concentratia of
chemicals, and gas/chemical velcoity,
should be considered, as a minimum,
along with the corrosive nature of the
chemical towhich the sprinklerswili be
exposed.
An intermediate level versions of the
Series TY-FRB Pendent Sprinklersare
detailed in Technical Data Sheet
TFP356, and Sprinkler Guards are de-
tailed in Technical Data Sheol TFP780
WARNBVGS
The Series TY -FRB Sprinklers de-
scribed herein must be installed and
maintained in compliance with this
document as wellas with the applica-
ble standards of the National Fire Pro-
section Association, in addition to the TY3231 - Uptight 8.OK,
standards otany otherauthotitieshav-
ingiurisdiodon. Failure to do so may TY4231 - Pendent 8.OK, 3/4'NPT
Impair the performance of these de-
Vices. Technical
The own or is responsible for main tain-
ing their tiro protection system and de- Data
vices in proper operating condition.
The installing contractor or sprinkler Approvals
manufacturer should be contacted UL and GUL Listed.
with any questions.
Model /Sprinkler
Identification
Numbers
TY1131 - Upright 2.8K,112 "NPT
TY1231 - Pendent 2.8K,1/2 "NPT
TY2131 - Upright 42K,1r2 "NPT
TY2231 - Pendent 4.2K, 12`NPT
TY3131 - Upright 6.6K,1t2'NPT
FM, LPCB. and NYC Approved.
(Rotor to Table A for complete approval
information including corrosion resis-
tant status.)
Maximum Working Pressure
175 psi (12,1 bar)
Discharge Coefficient
K = 2.8 GPM/psi112 (40,3 LPMibar `112)
K = 42 GPM/psi'/'! (60,5 LPM/)arv2)
K = 5.6 GPM/psi112 (80,6 LPM/barv2)
K = 8.0 GPM/psi1 12 (115,2 LPM/barv2)
Temperature Ratings
Refer to Table A arxf B
Pagel of a JULY, 2004 TFPt71
/
NFPA 13 - 2007 EDITION
24.2 ACCEPTANCE REQUIREMENTS.
24.2.1 - HYDROSTATIC TESTS.
24.2.1.1 - UNLESS PERMITTED BY 24.2.1.2 THROUGH 24.2.1.6, ALL PIPING AND ATTACHED
APPURTENANCES SUBJECTED TO SYSTEM WORKING PRESSURE SHALL BE HYDROSTATICALLY
TESTED AT 200 PSI (13.8 BAR) AND SHALL MAINTAIN THAT PRESSURE WITHOUT LOSS FOR 2
HOURS.
24.2.1.2 PORTIONS OF SYSTEMS NORMALLY SUBJECTED TO SYSTEM WORKING PRESSURES IN
EXCESS OF 150 PSI (10.4 BAR) SHALL BE TESTED AS DESCRIBED IN 24.2.2.1 AT A PRESSURE OF
50 PSI (3.5 BAR) IN EXCESS OF SYSTEM WORKING PRESSURE.
24.2.1.3 WHERE COLD WEATHER WILL NOT PERMIT TESTING WiTH WATER, AN INTERIM AiR
TEST SHALL BE PERMITTED TO BE CONDUCTED AS DESCRIBED IN 24.2.3.
24.2.1.4 MODIFICATIONS AFFECTING 20 OR FEWER SPRINKLERS SHALL NOT REQUIRE TESTING
IN EXCESS OF SYSTEM WORKING PRESSURE.
24.2.1.5 WHERE ADDITION OR MODIFICATION IS MADE TO AN EXISTING SYSTEM AFFECTING
MORE THAN 20 SPRINKLERS, THE NEW PORTION SHALL BE ISOLATED AND TESTED AT NOT
LESS THAN 200 PSI (13.8 BAR) FOR 2 HOURS.
24.2.1.6 MODIFICATIONS THAT CANNOT BE ISOLATED, SUCH AS RELOCATED DROPS, SHALL
NOT REQUIRE TESTING IN EXCESS OF SYSTEM WORKING PRESSURE.
2009 FLORIDA STATUTESJ CHAPTER 6331 FIRE PREVENTION AND CONTROL
PERSONS CERTIFIED AS A CONTRACTOR I, CONTRACTOR II, OR CONTRACTOR IV UNDER THIS
CHAPTER MAY DESIGN FORE PROTECTION SYSTEMS OF 49 OR FEWER SPRINKLERS, AND MAY
DESIGN THE ALTERATIOiW OF AN EXISTING FIRE SPRINKLER SYSTEM IF THE ALTERATION
CONSISTS OF THE RELOCATION, ADDITION, OR DELETION OF NOT MORE THAN 49 SPRINKLERS,
NOTWITHSTANDING THE SIZE OF THE EXISTING FIRE SPRINKLER SYSTEM.
CONTRACTOR - DEVELOPED PLANS MAY NOT BE REQUIRED BY ANY LOCAL PERMITTING
AUTHORITY TO BE SEALED BY A REGISTERED PROFESSIONAL ENGINEER.
SCHEDULE
1. NEW MECH -TYPE TEE
4
2. EXISTING BRANCHUNE.
5 3. ARMOVER
NOTE:
4. 1" DROP. COUPONS TO BE ATTACHED TO ALL
® 5. NEW FIRE SPRINKLER HEAD NEW MECH TEES.
NEW CONNECTION DETAIL
STEEL I BEAM
OR BAR JOIST
ALL THREADED
HANGER ROD
PIPE
-STOP BEAM CLAMF
(w /lock nut)
MAXIMUM HANGER SPACING (FT.)
N.T.S.
POWDER DRIVEN STUDS MAY
BE USED IN LIEU OF LISTED
CONCRETE INSERTS.
d
+'•. SLAB
DROP -IN ANCHOR
3/8" ROD 1 3/8" POWDER
COUPLING --�� DRIVEN STUD
3/8" ALL
THREADED ROD
ADJUSTABLE S"1%
LOOP HANGER —
HAiGER ROD SIZES
UP `0 4" PIPE
3/8" DIA.
PIPE SIZE (IN.)
3/4
1
1/4
1 112
2
THREADED LIGHTWALL
FIRE SPRINKLER
SCHEDULE
STEEL PIPE
N/A
12
2
12
12
STEEL PIPE EXCEPT
TYPE /DESCRIPTION
TEMP(7)
K
RESPONSE
THREADED LIGHTWALL
N/A
12
2
15
15
PIPING SUPPORT DETAIL
N.T.S.
:(SIZE VARIES)
:ES 1" TO 4 ")
GENERAL NOTES
1 - ALL PIPING, HEADS, HANGERS AND SYSTEM CMPONENTS TO BE SPACED AND INSTALLED
AS PER THE LATEST APPLICABLE EDITION OF NFR -13, APPROVING AUTHORITY HAVING
JURISDICTION AND ALL STATE AND LOCAL CODES
2 - ORDINARY HAZARD OCCUPANCIES (STORAGEXREAS) - 130 SQ. FT. MAXIMUM SPACING PER
FIRE SPRINKLER HEAD. LIGHT HAZARD OCCUPANIES (OFFICES AND CORRIDORS) - 225 SQ. FT.
MAXIMUM SPACING PER FIRE SPRINKLER HEAD. KTENDED COVERAGE HEADS TO BE SPACED
IN ACCORDANCE WITH THE LISTING FOR THE INDIiDUAL HEAD.
3 - PiPING TO BE INSTALLED CONCEALED ABOVE IROPPED CEILINGS EXCEPT AS NOTED IN
EXPOSED CEILING AREAS.
4 - LINE PIPING 1" - 2" TO BE THREADED "XL" WITI-SCREWED FITTINGS OR APPROVED
ACCEPTABLE EQUAL.
5 - PROVIDE FIRE STOPPING ON ALL PENETRATIOIS THROUGH FIRE WALLS
SCOPE OF WORK:
EXISTING FULLY PROTECTED O'-FICE BUILDING.
ADD FIRE SPRINKLER HEADS TO PROVIDE COVERAGE
AS SHOWN ON PLAN.
5�
o�
O . _.6 Q
Denis K. Solano
P.E. 56902 S.I. 2046
Solver Structural Partnership, Inc.
7500 N W 25th ST Phone (305) 592 -9396
SUITE # 205 Fax. (305) 599 -9347
• _Miami, FI 33122 E -Mail solverstruct@c.s com
WEB SITE WVVW SOLVERSP COM
- - D =SIGN - INSPECTION - INVESTIGATION - REPORTS
F-1
W 6M
FIRE SPRINKLER
SCHEDULE
ice.
Z
Z
SYM
ONT
TYPE /DESCRIPTION
TEMP(7)
K
RESPONSE
NPT
MFG,
MODEL
SIN
ESCUTCHEON
(ONN.
NOTES /INTENDEFUSE
r:)W0M U2 E-
RATING
FACTOR
0
02
NEW PENDENT
a
155
5.6
QUICK
112"
TYCO
TY -FRB
TY -3251
RECESSED
Aft
0
EX. PENDENT
155
5.6
QUICK
1/2"
'-'
U
rF�
p
C-) V) �
�CO0F'w�l�
��
°'
J
U]
111
<
Gl
O
30
1:2
0
/wy
w
N
W
d
M
F
iz
TOTAL NUM
NOTES
�.�' -��, •;�
1. ALL FIRE
SPRINKLERS SHALL HAVE A U.L.
APPROVED CORROSION
RESISTANT COATING WHERE EXPOSED
���
TO OUTSIDE AIR, CHEMICALS, MOISTURE, OR 0
OTHER
CORROSIVE VAPORS SUFFICIENT TO
CAUSE CORROSION OF
SUCH DEVICES.
�O
d
C
OQ'
Denis K. Solano
P.E. 56902 S.I. 2046
Solver Structural Partnership, Inc.
7500 N W 25th ST Phone (305) 592 -9396
SUITE # 205 Fax. (305) 599 -9347
• _Miami, FI 33122 E -Mail solverstruct@c.s com
WEB SITE WVVW SOLVERSP COM
- - D =SIGN - INSPECTION - INVESTIGATION - REPORTS
F-1
ice.
Z
Z
z
�wWV) E
H <W Q',
r:)W0M U2 E-
04.
E- . a.
1-'
a
6
a l C) C4
0
C \J w
'-'
U
rF�
p
C-) V) �
�CO0F'w�l�
��
°'
J
U]
111
<
Gl
O
30
1:2
0
/wy
w
N
W
d
M
F
iz
d
W
E-
IY
N
i�
H-1
t/]
W
ASS
M
Z
m
m
W
x
ad
V_
od
Z
U
o
W
Q
W
c
Q
o
W
Z_ U_'
W
=-
<W
y,1
M
P
(n
o
a
a
a
(I.
r?3
rr?
=
x
3
•
C.)
F_
r�
►�--�
cc)
C
O
Cd
U
UD
CC
•--1
U)
IL4
,'r
a~
t
C�
w
cf)
cc
CQ
.�
0
a�
s�
P-4
r--�
°
a
co
0
LO
�WM
W
V3
I7—
o
�
CO
W \')
'
UWQ
CL >0
a
W
O
U)
H
I—W_..
VJ VJ
�ZQ
W 2
M�
Cfl
U
0
U
Q
w
o
Of
a
�
Z
o
U
srzlxm #
NFPA
13
�
DRAWN BY:
A.A.F.I., IIIC.
CHECKED BY:
TOTAL A /S:
DATE:
07/26/2012
SCALE:
AS NOTED
AHa:
CONTRACT i
SHEET I
FP-
I O F 1